攪拌車在使用時要注意如果設備沒有潤滑油，設備不允許運轉，而且要正確安裝，確保以及長期穩定運行；另外日常維護中，應檢查設備部件是否損壞等；下面就詳細介紹相關內容。
When using the mixer truck, it should be noted that if the equipment does not have lubricating oil, the equipment is not allowed to operate, and it should be installed correctly to ensure safe and long-term stable operation; In addition, during daily maintenance, check whether the equipment components are damaged, etc; The relevant contents are described in detail below.
小型混凝土攪拌車使用注意事項：
Precautions for safe use of small concrete mixer:
1、攪拌車需要正確安裝和使用，以確保和長期穩定運行。
1. The mixer truck needs to be installed and used correctly to ensure safe and long-term stable operation.
2、安裝人員應具備相應的資質和熟悉機械設備安裝知識的人員進行安裝工作。
2. The installation personnel shall be qualified and familiar with the installation knowledge of mechanical equipment.
3、攪拌器應垂直安裝，垂直度偏差不超過5度。
3. The agitator shall be installed vertically, and the verticality deviation shall not exceed 5 degrees.
4、禁止在配料攪拌系統中攪拌高粘度的固體和液體。
4. It is forbidden to mix solids and liquids with high viscosity in the batching and mixing system.
5、電機和軸承的溫度不能超過75℃。
5. The temperature of motor and bearing shall not exceed 75 ℃.
6、沒有潤滑油，電機、軸承和變速箱不能運轉。
6. Without lubricating oil, the motor, bearing and gearbox cannot operate.
7、攪拌器軸和葉片不能在彎曲或變形的情況下運行。如果軸彎曲或刀片變形，請立即停機進行處理或更換。
7. The agitator shaft and blades cannot operate under bending or deformation. If the shaft is bent or the blade is deformed, stop the machine immediately for treatment or replacement.
8、攪拌系統運行過程中，嚴禁雜物進入反應池，以免損壞攪拌軸和葉片。
8. During the operation of the mixing system, sundries are strictly prohibited from entering the reaction tank to avoid damaging the mixing shaft and blades.
9、如果人們需要進入反應罐進行清潔或維護，必須切斷電機電源，并懸掛“禁止關閉”的警告標志。在手動清洗和維護反應罐時，必須有專人在反應罐外進行監督。
9. If people need to enter the reaction tank for cleaning or maintenance, they must cut off the power supply of the motor and hang a warning sign of "no shutdown". When manually cleaning and maintaining the reaction tank, special personnel must be assigned to supervise outside the reaction tank.
10、攪拌系統運行一段時間后，如果反應罐底部有沉淀物、雜質和雜物，應及時停止，用清水沖洗或人工清理，以確保攪拌器的運行。
10. After the mixing system operates for a period of time, if there is sediment, impurities and sundries at the bottom of the reaction tank, it should be stopped in time, washed with clean water or manually cleaned to ensure the safe operation of the mixer.
小型混凝土攪拌車的日常維護
Daily maintenance of small concrete mixer
1、檢查油泵需要需要進行注入油脂，而且需要檢查空氣壓縮機曲軸箱中的潤滑油質量如何是否需要進行更換。
1. Check whether the oil pump needs to be filled with grease and whether the lubricating oil in the crankcase of the air compressor needs to be replaced.
2、潤滑點一定要進行潤滑，設備的卸料門軸，每個儲料斗和稱重桶門軸，膠帶輸送機等地方都是需要進行潤滑的。
2. The lubrication points must be lubricated. The unloading gate shaft of the equipment, the gate shaft of each storage hopper and weighing bucket, and the belt conveyor all need lubrication.
3、還需要檢查刀片還有攪拌臂等磨損情況，如果磨損的比較嚴重需要進行修補或者進行進行更換。將攪拌器的振動器連接螺栓擰緊。
3. It is also necessary to check the wear of blades and mixing arms. If the wear is serious, it needs to be repaired or replaced. Tighten the connecting bolts of the vibrator of the mixer.
6、檢查設備里面的接觸器，還有中間繼電器的靜態繼電器有沒有損壞。
6. Check whether the contactor in the equipment and the static relay of the intermediate relay are damaged.
7、設備每次運行結束之后，都需要清理干凈設備以備下次繼續使用。
7. After each operation, the equipment needs to be cleaned for further use.
8、在冬天比較寒冷的季節，設備里面不要殘留多余的水，在使用結束之后要排出干凈。
8. In cold winter, do not leave excess water in the equipment, and drain it after use.
以上就是今天為大家介紹的關于問題以及注意事項的全部內容，希望對大家能有所幫助，想要了解更多內容可以電話聯系我們或者關注我們的網站http://www.qirongguanjia.cn，我們的工作人員會及時與您取得聯系。
The above is all about the problems and precautions introduced to you today. I hope it can help you. If you want to know more, you can contact us by phone or follow our website http://www.qirongguanjia.cn , our staff will contact you in time.
