我們知道，全自動混凝土攪拌車的維護可以概括每日每周每月每年等階段，這表明了攪拌車維護的重要性。讓我們看一下全自動混凝土攪拌車每星期應該檢查的項目。

As we know, the maintenance of automatic concrete mixer can be summarized into daily, weekly, monthly and annual stages, which shows the importance of mixer maintenance. Let's take a look at the items that the automatic concrete mixer should check every week.

1、檢查鋼絲繩磨損情況并在其表明涂少許潤滑油，鋼絲繩磨損到一定程度后，應進行更換。

1. Check the wear of wire rope and apply a little lubricating oil when it is indicated. After the wire rope is worn to a certain extent, it should be replaced.

2、檢查減速箱油面，油泵油量，檢查各潤滑部位的情況，往料斗滾輪軸承及滑輪軸承加注潤滑油。

2. Check the oil level of the gearbox and the oil volume of the oil pump, check the condition of each lubricating part, and add lubricating oil to the hopper roller bearing and pulley bearing.

3、供水裝置要保持清潔，以免堵塞，對吸水閥檢查清洗一次。

3. The water supply device shall be kept clean to avoid blockage. The suction valve shall be checked and cleaned once.

4、檢查行程開關搖臂是否松動，如有松動應予必要調整。

4. Check whether the rocker arm of the travel switch is loose, and adjust it if necessary.

5、檢查葉片連接螺栓，支撐臂連接螺栓是否松動酌情調整，葉片與筒壁間的間隙大間隙5mm并作必要的擰緊。

5. Check whether the connecting bolts of the blade and the support arm are loose, and adjust them as appropriate. The gap between the blade and the cylinder wall is 5mm and tighten it as necessary.

6、檢查電氣箱中接觸器觸頭情況。

6. Check the contact of the contactor in the electrical box.

7、擰開放淤塞，檢查軸端密封，作必要的調整修理和更換。

7. Unscrew the silting, check the shaft end seal, and make necessary adjustment, repair and replacement.

全自動混凝土攪拌車定期應該檢查的項目：

Items that should be checked regularly for automatic concrete mixer:

1、對卷揚提升制動器進行檢查并作適當?shù)恼{(diào)整。

1. Check the winch lifting brake and make proper adjustment.

2、對水泵，節流閥進行檢查，是否有漏水現象。

2. Check the water pump and throttle valve for water leakage.

3、對開式齒輪進行檢查涂抹潤滑油并調整皮帶松緊。

3. Check and apply lubricating oil to the open gear and adjust the belt tightness.

4、檢查葉片，襯板的磨損情況，并酌情更換。

4. Check the wear of blades and lining plates and replace them as appropriate.

小編提醒廣大用戶：混凝土攪拌車的安裝，應由專門的人員按出廠說明規定進行，并應在技術的主持下組織調試，在各項技術性能指標全部符合規定并經驗收合格后，方可使用。更多相關內容就來我們網站http://www.qirongguanjia.cn咨詢了解！

The small editor reminds users that the installation of the concrete mixer shall be carried out by special personnel according to the factory instructions, and the commissioning shall be organized under the auspices of the technology. The concrete mixer can be used only after all the technical performance indicators meet the requirements and pass the acceptance. More relevant content will come to our website http://www.qirongguanjia.cn Ask about it!