夏天是容易發生火宅的季節，不管是外出還是工作，都需要小心注意，特別是對于攪拌車這一領域來說，發生這種事故不僅讓自身的受到威脅，也會讓公司受到一定的損失，所以做好預防工作很是關鍵。全自動攪拌車廠家為您講內容。
Summer is a season where fire accidents are easy to occur. No matter when you go out or work, you need to be careful. Especially in the field of mixer trucks, the occurrence of such accidents will not only threaten your own safety, but also cause certain losses to the company. Therefore, it is very important to do a good job in prevention. The full-automatic mixer manufacturer will tell you the content.
(1)發動機運轉時或搖車時，不許往化油器口倒汽油。向化油器內加注汽油以提高缸內混合氣的濃度，這樣做雖然在發生油不進缸故障時有利于啟動，但對其它原因造成的故障是無濟于事的，而且這樣做也可能造成回火，燒傷人員和燒毀車輛等危害。
(1) Do not pour gasoline into the carburetor when the engine is running or when the vehicle is shaking. Fill the carburetor with gasoline to increase the concentration of the mixture in the cylinder. Although this is conducive to startup in case of failure of oil not entering the cylinder, it is not helpful to the failure caused by other reasons, and it may also cause backfire, burn personnel and burn vehicles.
(2)保養汽油濾清器時，不提倡用汽油燒濾清器芯子。許多人在保養汽油濾清器時，喜歡用汽油燒陶瓷濾芯的辦法來濾芯上的雜質。這樣做的危害是容易失火，同時對于濾芯的壽命有影響。
(2) When maintaining the gasoline filter, it is not recommended to burn the filter core with gasoline. Many people like to burn ceramic filter element with gasoline to remove impurities on the filter element when maintaining the gasoline filter. The danger of this is that it is easy to catch fire and has an impact on the life of the filter element.
(3)在油庫內，不許用短路劃火的辦法來檢查蓄電池存電情況。因?yàn)樵谕L(fēng)不好的小油庫內，往往還放置輪胎、蓄電池、篷布等器材，地面上有灑落的汽油，劃火時產生的火花很可能將空氣中的油分子引燃。
(3) In the oil depot, it is not allowed to use the method of short-circuit ignition to check the battery storage. Because in small oil depots with poor ventilation, equipment such as tires, batteries, tarpaulins and so on are often placed, and gasoline is scattered on the ground. The sparks generated during the fire are likely to ignite the oil molecules in the air.
(4)油罐車的拖地鐵鏈不許纏繞在大梁上。油料和其它物質一樣，當與另一物體相互摩擦?xí)r也會產生靜電。這種靜電跳火，可能將燃料點燃引發火災。所以在油庫上要裝有接地的地線，油罐車上也要裝有一條接地的鐵鏈，以防止油罐內產生靜電火花，此鐵鏈不能隨便纏繞在大梁車架上，須放在地面上，并且拖地段不少于50厘米。
(4) The towing iron chain of the oil tanker shall not be wound on the girder. Like other substances, oil will generate static electricity when it rubs against another object. This electrostatic fire may ignite the fuel and cause a fire. Therefore, a grounding wire shall be installed on the oil depot, and a grounding iron chain shall be installed on the oil tank truck to prevent static sparks in the oil tank. The iron chain shall not be wound on the girder frame at will, but shall be placed on the ground, and the towing section shall not be less than 50cm.
(5)不準經常采用吊火法。有時汽車火花塞會有積炭，當某缸的積炭嚴重時，該缸就不能正常工作，為了使該缸能正常運行，采用缸外“吊火”的方法(將火花塞與高壓線之間留3毫米—4毫米的間隙)，以提高火花塞電極跳火的能量，使該缸恢復工作。
(5) It is not allowed to frequently use the hanging fire method. Sometimes there is carbon deposit in the spark plug of an automobile. When the carbon deposit of a certain cylinder is serious, the cylinder can not work normally. In order to make the cylinder work normally, the method of "hanging fire" outside the cylinder (leaving a gap of 3mm-4mm between the spark plug and the high-voltage line) is adopted to improve the energy of spark plug electrode and restore the cylinder to work.
但一般的“吊火”方法稍不注意就容易脫落。如果缸體上有滴落的汽油，就容易發生火災。因此它只是一種臨時性補救措施。正確處理應該是及時清洗保養火花塞，盡量避免使用“吊火”法。
However, the general "hanging fire" method is easy to fall off without paying attention. If there is gasoline dripping on the cylinder block, it is prone to fire. Therefore, it is only a temporary remedy. The correct treatment should be to clean and maintain the spark plug in time, and try to avoid using the "hanging fire" method.
攪拌車防火注意事項有以上幾種，您可以作為參考內容使用，更多注意事項就來我們網站http://www.qirongguanjia.cn咨詢了解吧！
There are several fire precautions for mixer trucks. You can use them as reference. For more precautions, please visit our website http://www.qirongguanjia.cn Consult and understand!
